- DL manuals
- Thermador
- Grill
- CGBD30RX
- Care & Use Manual
Thermador CGBD30RX Care & Use Manual
Summary of CGBD30RX
Page 1
For thermador char glo ® outdoor barbecues models: cgbd30rx • cgbd36rx cgbd48rsbx • cgbd48rx care & use manual cgbd30rx cgbd36rx cgbd48rsbx.
Page 2
A special message to our customers thank you for selecting the thermador® char glo® outdoor barbecue. We recommend that you take time to read this entire booklet before using your new appliance for the first time. This booklet contains suggestions we believe will be helpful as well as directions for...
Page 3: Table of Contents
Page 1 table of contents warnings for safe gas installations ....................................................... 2, 3 for your safety ........................................................................................................... 2 what to do if you smell gas ...........................
Page 4
Page 2 tested in accordance with ansi z21.58-1995, ansi z21.58a-1998, standard for outdoor cooking gas appliances and can/cga 1.6-m95, can/cga 1.6a-m98, standard for outdoor cooking gas appliances. This unit is for outdoor use only in a well-ventilated area. Not to be used in a building, garage or a...
Page 5
Page 3 important information this outdoor gas cooking appliance is not intended to be installed in or on recreational vehicles and/or boats. Always inspect the natural gas or lp gas hose assembly before each use of the appliance. If there is evidence of excessive abrasion or wear, or if the hose is ...
Page 6
Page 4 section 1: safety practices to avoid personal injury important safety instructions read all instructions before using your barbecue safety precautions when properly cared for, your new thermador® char glo® barbecue has been designed to be a safe and reliable appliance. However, extreme care m...
Page 7
Page 5 for your safety for outdoor use only. If stored indoors, detach and leave tank outdoors. Avertissement pour utlilisation a la l’extérieur seulement. Si l’appareil est entreposé à l’intérieur, enlever les bouteilles et les laisser a l’extérieur. For your safety an lp tank not connected for use...
Page 8
Page 6 section 2: model and parts identification 2 3 4 8 7 6 5 9 10 11 12 13 14 15 on front of hood model cgbd48rsbx 1 11. Control knobs 12. Ignition switch 13. Lighting instructions 14. Side burners (cover shown on page 7) 15. Data rating label (on underside of unit) literature pack contents: ✓ pro...
Page 9
Page 7 model cgbd36rx 2 3 8 7 6 5 9 10 11 13 on front of hood 12 14 7 1 model cgbd48rx.
Page 10
Page 8 1 2 3 4 8 7 6 5 9 11 12 13 14 on front of hood model cgbd30rx 1. Hood / lid with handle 2. Thermometer gauge and thermador nameplate 3. Infrared rotisserie burner 4. Rotisserie motor assembly 5. Rotisserie igniter assembly 6. Grill grates 5 on model cgbd30rx 7. Radiants (heating baffles shown...
Page 11
Page 9 installation of lp (propane) gas tank lp (propane) lighting instructions • raise hood/lid. • turn tank valve to open gas supply. • light one burner at a time. • turn control knob to the "lite" position and immediately press and hold the ignition switch. The burner will light within 4 to 10 se...
Page 12
Page 10 section 3: using your char glo ® barbecue thermometer infrared knob grill burner knobs smoker knob surface burner knobs grate (model cgbd48rsbx shown).
Page 13: Warning
Page 11 if you smell gas, do not attempt to light any burners. 1. Make sure that all control knobs are turned to the off position. 2. Open the hood to allow any accumulated gas to dissipate and wait five minutes before trying to light the unit. 3. If the smell of gas is still present, turn off the g...
Page 14
Page 12 main and smoker burners: 1. Raise hood / lid. 2. Light only one burner at a time. 3. Always turn control knob to the “lite” position and immediately press and hold the ignition switch. The burner will light within 4 -10 seconds. 4. Release ignition switch after burner ignites. Look for the f...
Page 15
Page 13 follow these steps to light the main burners manually: 1. Turn off all the burners. 2. Wait 5 minutes to allow any accumulated gas to dissipate. Use a long stem match to light manually: 3. Remove the grill grates. 4. Find the ports on top of the burner by looking through the opening at the e...
Page 16
Page 14 using the grill 1. Refer to the grilling chart to select the heating method: direct or indirect. 2. Follow directions for lighting the burner/s on page12. 3. Preheat the grill about 10 minutes with the hood down. 4. Estimate the grilling time according to the suggestion on the grilling chart...
Page 17
Page 15 using the smoker 1. Soak wood chips in water as directed on the package. This may take as long as 30 minutes. 2. Prepare the food for cooking on the grill or rotisserie. 3. Once chips are soaked, fill back half of tray. 4. Light smoker burner according to directions on page 12, then close tr...
Page 18
Page 16 grilling chart measuring heat settings: knobs have high and low setting for flame adjustment. Heat settings indicated above are approximate. Beef: ground beef patties 3/4" thick direct med hi no pink color 10 - 15 min. Total roasts: rib eye, sirloin 4 to 6 lbs indirect med/o/med 140 ° med ra...
Page 19
Page 17 grilling chart thickness/ grill burner internal doneness approximate food item weight method setting or temperature (ºf) grilling time chicken: breasts, boneless pounded to 3/4 direct medium juices run clear 8 - 12 min. Total inch thick pieces 2 - 3 lbs. Direct med low 170 ° - breast 25 - 45...
Page 20
Page 18 section 5: the rotisserie and assembly arrange food on the skewer 1. Slide one fork onto the skewer as shown above, according to the model. 2. Insert the skewer through the center of the food and center it lengthwise. This will align it with the infrared burner. 3. Slide the second fork onto...
Page 21
Page 19 9. If two birds are done simulta- neously, position them with the wings and tail in the same direc- tion on the skewer. To balance, truss one bird with breast up and second with breast down. Birds should be about the same weight in order to cook at the same time. 10. Use a portable thermomet...
Page 22
Page 20 rotisserie internal doneness approximate meat item weight setting or temperature (ºf) grilling time beef roasts: rib eye 4 - 6 lbs. Hi 145º - med rare 15 - 20 min. Per lb. Sirloin tip 150º - med 20 - 25 min. Per lb. Rib, boneless poultry** chicken, whole 3 - 5 lbs med 170º - breast 1 hr. 10 ...
Page 23
Page 21 general side burner information • side burners are only available on model cgbd48rsbx. • each burner is rated at 15,000 btu on high. • choose a pan base to fit the flame size. The flame should never extend beyond the base of the pan. • never turn on a side burner without removing the cover. ...
Page 24
Page 22 quick clean method for grates 1. Immediately after cooking, turn off the burners. Fill a container with very hot water. 2. Using a long handled, brass barbecue brush dipped in hot water, scrub the hot grates. Use a heavy mitt to protect your hand from the heat and steam. 3. Repeat. Scrub eac...
Page 25
Page 23 cleaning chart as a safety measure, do not store cleaners in the storage drawers in the barbecue. Part and material suggested care exterior finish - stainless steel finish protector: stainless steel magic ® and ez brite ® stainless steel the quality of this material resists most stains and p...
Page 26
Page 24 __________________________________ model number __________________________________ serial number __________________________________ date of purchase __________________________________ dealer’s name __________________________________ dealer’s phone number __________________________________ se...
Page 27: Full One Year Warranty
Page 25 warranty section 9: warranty full one year warranty covers one year from the date of installation or date of occupancy for a new previously unoccupied dwelling. Save your dated receipt or other evidence of the installation/occupancy date. 5- year limited warranty covers the rotisserie burner...
Page 28
5551 mcfadden avenue, huntington beach, ca 92649 • 800/735-4328 eco15639 • 08-04-440c • © thermador corporation 1998 • litho u. S. A. 8/99 specifications are for planning purposes only. Refer to installation instructions and consult your countertop supplier prior to making counter opening. Consult w...